Volkswagen Golf Mk7 Owners Manual: Introduction

This chapter contains information on the following subjects:

 → Contents of the breakdown set

 → Preparation

 → Sealing and inflating tyres

 → Test after driving for 10 minutes

You can use the breakdown set (tyre mobility set) to safely seal any tyre damage caused by foreign bodies or punctures (up to 4 mm in diameter). Do not remove foreign objects (e.g. screws or nails) from the tyre!

Once the sealant has been added to the tyre, the tyre pressure must be checked again after approximately 10 minutes of driving.

Seek expert assistance if more than one vehicle tyre is damaged. The breakdown set is only designed for filling one tyre.

Only use the breakdown set if the car is parked in a safe place, you are familiar with the required actions and safety procedures, and you have access to the correct breakdown set. Seek expert assistance if this is not the case.

The tyre sealant must not be used:

• If the rim is damaged.

• If the outside temperature is below -20°C (-4°F).

• If there are cuts or punctures in the tyre that are larger than 4 mm.

• If the tyre pressure is very low or the tyres are flat.

• If the use-by date on the tyre filler bottle has expired.

Additional information and warnings:

• Vehicle key set

• Braking, stopping and parking

• Wheels and tyres

• In an emergency

• Hub caps

WARNING

Using the breakdown set can be dangerous, especially if the tyres are inflated at the roadside. Please note the following steps in order to reduce the risk of serious injuries:

• Stop the vehicle as soon as possible and when safe to do so. Park the vehicle at a safe distance from moving traffic in order to fill the tyre.

• The ground should be firm and level.

• All passengers, and children in particular, must be at a safe distance and away from your area of work.

• Switch on the hazard warning lights to warn other road users.

• The breakdown set should only be used if you feel confident with carrying out the procedure. If not, seek expert assistance.

• Tyres repaired with the breakdown set are intended for temporary, emergency use only. They should only be used until you can reach the nearest qualified workshop.

• Tyres that have been repaired using the breakdown set should be replaced as soon as possible.

• Sealant is hazardous to health and must be washed off immediately if it gets onto the skin.

• The breakdown set must be stored out of the reach of children.

• Never use a vehicle jack, even if it is approved for the vehicle.

• Always switch off the engine, switch on the electronic parking brake and move the selector lever to the position P or select a gear on a manual gearbox in order to reduce the risk of unintended vehicle movement.

WARNING

Tyres that have been filled with sealant will not handle in the same way as a standard tyre.

• Never drive faster than 80 km/h (50 mph).

• Avoid full acceleration, sudden braking and fast driving through bends in the road.

• Drive for just 10 minutes at no more than 80 km/h (50 mph) and then check the tyre.

Dispose of used or out-of-date sealant in accordance with legal requirements.

You can get a new tyre filler bottle from a Volkswagen dealership.

Observe the separate instructions from the manufacturer of the breakdown set.

Questions & answers

Introduction — Volkswagen Golf Mk7

When should I use the Golf Mk7 breakdown set instead of a spare wheel?

If your car was delivered without a jack and spare — some Golf Mk7 models come with the breakdown set as standard. It is also useful as a faster temporary fix before reaching a workshop.

What size puncture can the Golf Mk7 breakdown set seal?

Punctures from foreign bodies (nails, screws) up to approximately 4 mm in diameter in the tread area. Larger holes or sidewall damage require professional repair or tyre replacement.

Does the Golf Mk7 breakdown sealant expire?

Yes. The sealant bottle has an expiry date printed on it. Replace it before that date to ensure it works when needed.